Tiffin Drivers: Is It Time to Replace Your PCV Valve?
June 7, 2020
The crankcase is the lower part of the engine where the crankshaft is housed and where the engine oil lives. The crankshaft is connected to the pistons that power the engine.
When you are diving around Tiffin, fuel is burned in your vehicle engine, it pushes the pistons down and the crankshaft rotates and sends power to the transmission. Some of the explosive gases from combustion squeeze past the pistons and down into the crankcase.
Now this gas is about 70% unburned fuel. If it were allowed to remain in the crankcase, it would contaminate the oil and quickly turn it to sludge. Sludge is like Vaseline and clogs passages in the engine, leading to damage.
Also, the pressure build up would blow out seals and gaskets. So in the old days, there was just a hose that vented the crankcase out into the air. Obviously, not good for our air quality in Tiffin, Ohio.
Enter the PCV valve. It's a small, one-way valve that lets out the gases from the crankcase and routes them back into the air intake system where they are re-burned in the engine. Fresh air comes into the crankcase through a breather tube. This makes for good circulation in the crankcase. And that gets the air out. As you can imagine, however, the valve gets gummed up over time.
Your vehicle manufacturer usually recommends they be changed somewhere between 20,000 to 50,000 miles/30,000 to 80,000 kilometers. Unfortunately, PCV valve replacement is left out of some vehicle owner's manuals, but your friendly service advisor at Courtesy Auto Repair Plus, we will make sure your PVC is replaced if needed.
Courtesy Auto Repair Plus
967 Bon Air Ave
Tiffin, Ohio 44883
419-443-0797
http://www.courtesyautorepairplus.com
More articles from Courtesy Auto Repair Plus
Command Performance (Engine Air Filter)
May 31, 2026
The internal combustion engine in your vehicle counts on two things that mix together to be burned in the engine for power: fuel and air. Both are important, of course. If you run out of fuel, your engine wont run at all. Since theres plenty of air around, you wont run out of air, but you coul... More
Taking the Heat (Batteries in Hot Weather)
May 24, 2026
Quick question. Which is tougher on a vehicle's battery, the heat or the cold? Believe it or not, it's the heat. Think about it. The battery often sits in the engine compartment next to that motor generating lots of heat. That can accelerate corrosion in the battery and may even cause water i... More
Why People in Tiffin Hesitate to Get Their Vehicle Serviced
May 17, 2026
A recent report stated that over 80 percent of the vehicles on our Tiffin, Ohio, roads have one or more service or repair that's needed but hasn't been taken care of. Now that's a lot of undone service. That translates into something over 160 million vehicles in North America alone. Some of the n... More